PEMANFAATAN EKSTRAK KULIT BUAH DELIMA ( PUNICA GRANATUM ) SEBAGAI INHIBITOR KOROSI PADA PIPA BAJA KARBON

Reski Nur Ananda, Cristy Rahayu Manda, Frenly Adhe Pratama, Ahmad Imran, Fitri Oktafiani, Risna Risna

Abstract


This research examines the potential of pomegranate peel extract (Punica granatum) as an environmentally friendly green corrosion inhibitor to control the rate of corrosion in carbon steel pipes in the petroleum industry. Corrosion in carbon steel causes economic losses and safety hazards, while conventional synthetic inhibitors have a high cost and a bad impact on the environment. Pomegranate peel was chosen because it is an agro industrial waste rich in bioactive compounds such as tannins, flavonoids, polyphenols, and ellagic acid that are able to form a protective layer on the steel surface. The results showed that the administration of extracts with variations of 10 ml, 20 ml, and 30 ml was able to significantly reduce the corrosion rate, with a mass decrease of 23.98 g; 23.52 g; and 23.91 g respectively, much smaller than the inhibitor-free sample. Thus, the pomegranate peel extract shows promising potential as a natural corrosion inhibitor that may help reduce the corrosion rate of carbon steel while offering a more environmentally friendly alternative.


Full Text:

PDF

References


Andira, R., Zulnazri, Z., Bahri, S., Azhari, A., & Muarif, A. (2022). Pemanfaatan Ekstrak Daun Rambutan Sebagai Inhibitor Korosi Pada Plat Besi Dalam Media Air Payau. Chemical Engineering Journal Storage (CEJS), 2(3), 11-20.

Angela F, Harun H, Gazali A. A (2025) Pengaruh Penggunaan Ekstrak Tanin Dari Limbah Kulit Durian (Durio Zibethinus Murr) Sebagai Inhibitor Korosi Pada Medium Asam Klorida: Pengaruh Penggunaan Ekstrak Tanin Dari Limbah Kulit Durian (Durio Zibethinus Murr) Sebagai Inhibitor Korosi Pada Medium Asam Klorida. J Saintis, 6(1):276–84.

Anjani, A. D. S. (2023). Pengaruh Inhibitor Alami Dari Biji Nangka Terhadap Laju Korosi Baja Karbon Tinggi. JFT: Jurnal Fisika dan Terapannya, 10(1), 1-15.

Elnagar, M. E., Elabbasy, H. M., & Fouda, A. E. A. S. (2023). Evaluation of Punica granatum extract as an environmentally safe corrosion inhibitor for carbon steel in a solution of 1 M sulfuric acid. Indian Journal of Chemical Technology (IJCT), 30(3), 342-351.

Fahrizal, Y., & Sutjahjo, D. H. (2019). Pengendalian korosi pada baja rendah karbon (mild steel) dengan inhibitor ekstrak tanin dari daun sirsak pada media air laut dan udara. JPTM, 9(1), 9-16.

Marni, L. G. (2023). Review Pemanfaatan Kulit Buah Rambutan (Nephelium lappaceum L.) Sebagai Inhibitor Korosi. JSSIT: Jurnal Sains dan Sains Terapan, 1(1).

Mulyati, B. (2019). Tanin dapat dimanfaatkan sebagai inhibitor korosi. Jurnal Industri Elektro dan Penerbangan, 8(1).

Sianturi, R. L., Suyati, L., & Astuti, Y. (2021). Korosi Besi dengan Elektrolit H2SO4 dan Karakterisasi Produk. Greensphere: Journal of Environmental Chemistry, 1(2), 39-42.

Roni, K. A., Elfidiah, E., Yuliwati, E., & Marselia, B. (2022). Penambahan Inhibitor Ekstrak Daun Pepaya (Carica Papaya L.) Terhadap Pengaruh Laju Korosi Pada Baja Karbon Dalam Larutan Air Laut. Jurnal Redoks, 7(1), 28-35.

Sa’diyah, J., & Suharti, P. H. (2022). Pemanfaatan Psidium guajava dan Annona muricata sebagai green corrosion inhibitor terhadap penurunan laju korosi pada pipa baja karbon. Distilat Jurnal Teknologi Separasi, 8(4), 883–889.

Muflihun, S. (2021). Studi Pemanfaatan Kulit Semangka Sebagai Aditif Dalam Penanganan Korosi Pada Pipa Flowline Sumur Migas (Doctoral dissertation, Universitas Islam Riau)..

Yufita, E., Nur, M. I., Fatriah, F., & Jalil, Z. (2022). Pengaruh Ekstrak Kulit Buah Naga Merah dan Daun Trembesi sebagai Penghambat Korosi pada Baja A36 dalam Larutan HCl 3%. Indonesian Journal of Applied Physics, 12(1), 99-107.




DOI: https://doi.org/10.58267/petrogas.v8i1.211

Refbacks

  • There are currently no refbacks.